加大設計之粉碎室及篩網，粉料通過率高，充份利用粒子間之衝擊，粉碎效果佳，粉碎物細度均勻

The design of an enlarged pulverizing chamber and a screen which is with large area ensures a high efficiency for passing through of the material pulverized.
Fully use the impact effects among particles enables a superb pulverizing effect and even fineness of materials pulverized.

FEATURE:

High capacity bag filter system

Product Prices:Quoted price and Inquiry

申川超微粉碎機，配置於膨化設備工藝流程，飼料粉碎細度可達 60~100目、通過率 85-95%。尤其適合生產φ1.5以下的小顆粒膨化飼料。
迴轉式衝擊錘頭，粉碎能力大，單位能耗較省。
銀焊鎢鋼擊錘及特殊耐磨合金齒板，可調式帶動盤，使擊錘及齒板使用壽命更長。
特殊設設計之粉碎篩片，除增加粉碎效率外更可有效防止過大過輕之纖維通過，阻塞後面膨化鋼模，且搭配獨立式分級系統，更能有效地、犀利地分級產品

The materials can be ground to the fineness 60~100 mesh pass through 85~95%. Rotary swing hammer crushing the material easily with high speed. Good wearness hammer and teeth liner long using life and anti-wear character. Adjustable hammer swing diameter to match different material and also prolong the spare parts life. Generally, The hammer using life is about 1200-1500T.
The liners life is about 3000-5000T,lt is depend on the material component.
Unique screen under the hammer not only to increase grinding capacity but also prevent large and weightless fiber from passing through out and then to block the Die bole.
To match with sharp air separator ensure the fine powder producing.

Product Prices:Quoted price and Inquiry

申川單軸膨化機，經歷了 10 餘年的演變及客戶實際生產經驗回饋，
第五代的申川單軸膨化機更可依客戶的生產需求及不同的長徑比(一般單軸的長徑約11~15)，配比適當的轉速生產出φ0.8~20mm，各種不同品種粒徑的沉浮性飼料顆粒。最大內含油脂量可達8~10%，並可依客戶本身的需求，
搭配選用真空洩壓設備，製造高檔、低成本的沉水魚蝦料；或搭配防擦邊阻尼座，可延長螺旋使用壽命；及增加搓揉出料時間，對某些的特殊配方產生獨特的效果，獨特抗撓曲軸承箱設計可隨時調整主軸撓曲角度，防止螺桿與內套螺旋碰撞延長使用壽命

According to ten years evolve and customer s produce Experience feedback.
The fifth generation extruder, Furthermore, according to customer requirement that produce φ0.8~20mm various diameter pellet whatever sinking or floating. Material fat content could reach to 8~10%.
Optional pressure ventilator for high quality sinking feed. Optional Anti-Brush damper seat not only prolong the screw life but also increase material maintain time.
It is good for some special formula. Durable bearing housing to avoid crash between screw and sleeves.

Product Prices:Quoted price and Inquiry

特點:
◆ 長徑比15~20
◆ 可生產0.8mm顆粒
◆ 油脂含量可達18~20%
◆ 自清能力強
◆ 馬達直結傳動，動力損失少
◆ 兩螺牙同向推送物料捏和效果好

FEATURE:
◆length/diameter ratio 15~20
◆φ0.8mm diameter pellet
◆fat content 18~20%
◆Good screw self clean
◆Motor directly driving with high efficiency
◆Two screw rotate in the same direction with good mixing efficiency

Product Prices:Quoted price and Inquiry

鍋爐而來的高壓蒸氣，通過熱交換器，產生40℃~130℃之高溫（溫度可設定），
上接一抽風機，巨大吸力使顆粒成懸浮狀，此作用烘乾效果更佳，適用於水產養殖魚、鰻及一般顆粒產品成為8~12%的溼度含量，
具有體積小、不佔空間等特長，外層保溫，熱源不流失，可省能源消耗，烘乾產能大，結構穩固，消耗能源小，溫度風壓可依實際情況加以調整

The high pressure steam from boiler gets through heat exchanger to produce high temperature of 40℃~130℃ for adjustable.
It connect with blower with huge sucking force that make the water content of feeds under 8%.
The feeds is kept floating on the dryer screen plate that get good drying effects. It is good drying system for fish, eel and other aqua feeds.
It has compact size, which requires minimum space. The insulation of dryer can keep the heat and save the power.
Low power consumption is required. The main body is a sturdy structure.
The temperature and fan pressure can be set depending on real conditions

Product Prices:Quoted price and Inquiry

最新循環氣流式烘乾機的設計，大大降低了蒸氣能源的消耗，且更容易調整大顆粒及沉性料的烘乾機時效。
獲取內外一致的烘乾效果，環流式的熱氣回收系統及四層網板傳動，延長烘乾時間，增加翻動次數讓顆粒均勻受熱，更可準確控制烘乾水分含量。
可搭配選用溫度PID控制器及節流控制器，達到最佳的耗能控制(平均蒸氣消耗約100~150 公斤/飼料噸)。

The design of the new board dryer, to level down the steam consumption and easy to adjust the big size feeds and sinking feeds drying time. Getting the best efficiency.
The circulative hot air retrieving system and the nets transmitting of the four times to make pellets heating in even, then to extend the dry time.
It has precise controls this dry the moisture content .
It can choose the PID controller and the throttle controller to reach the best control. (The steam using average 100~150 kg/per feeds ton)

Product Prices:Quoted price and Inquiry